Product ID:ZINC-MOLYBDATE PRIMER COATING
MSDS Date:04/01/1998
FSC:8010
NIIN:01-285-1328
Status Code:A
MSDS Number: CLKNK

Emergency Phone: 800-424-9300

Info Phone: 206-244-8844

Preparer: ERNEST CARTER

Cage: 6F266

Telephone: 206-244-8844

Cage: 6F266

MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 2900 MG/M3;500 PPM

ACGIH TLV: 525 MG/M3;100 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Effects of Overexposure:SKIN: THIS MATERIAL MAY CAUSE IRRITATION.
INHALATION: EXCESSIVE EXPOSURE TO VAPORS CAN RESULT IN HEADACHE.
DIZZINESS, NAUSEA AND LOSS OF CONSCIOUSNESS. EYES: THIS MATERIAL
MAY BE AN EYE IRRITANT.
Medical Cond Aggravated by Exposure:NONE. WHEN USED IN ACCORDANCE WITH
SAFE HANDLING INSTRUCTIONS.

First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH LARGE
QUANTITIES OF WATER FOR 15 MINUTES. SWALLOWING: IF INGESTED DO NOT
INDUCE VOMITING. KEEP PERSON WARM AND QUIET AND GET MEDICAL
ATTENTION. INHALAT ION: REMOVE VICTIM TO FRESH AIR IMMEDIATELY.

Flash Point Method:TCC
Flash Point:=40.C, 104.F
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:0.7%
Upper Limits:6.0%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, OR WATER FOG.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY RUPTURE WHEN
EXPOSED TO EXTREME HEAT. WEAR SELF-CONTAINED BREATHING APPARATUS
WHEN EXPOSED TO VAPORS OR PRODUCTS OF COMBUSTION. VAPORS MAY FORM
EXPLOSIVE MIXTURE IN AIR AND MA Y BE IGNITED BY SPARKS, PILOT
LIGHTS, ETC.

Spill Release Procedures:VERMICULITE OR SAND PLACE MATERIAL INTO A
CLOSED CONTAINER.

Handling and Storage Precautions:DO NOT GET IN EYES. ON SKIN OR
CLOTHING. KEEP CONTAINERS CLOSED WHEN NOT IN USE.

Respiratory Protection:A CANISTER TYPE RESPIRATOR.
Ventilation:GENERAL VENTILATION IS REQUIRED DURING NORMAL USE.
Protective Gloves:CHEMICAL RESISTANT NITRILE, NEOPRENE OR RUBBER GLOVES
REQUIRED.
Eye Protection:WEAR FACE SHIELD OR CHEMICAL GOGGLES.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO PREVENT SKIN
CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.
PRECAUTIONS
Supplemental Safety and Health

Boiling Pt:B.P. Text:307-387 F
Melt/Freeze Pt:M.P/F.P Text:NONE
Decomp Temp:Decomp Text:NONE
Vapor Pres:2.6 MMHG@20C
Vapor Density:HEAVIER
VOC Pounds/Gallon:329
Viscosity:75-91 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:YELLOW VISCOUS LIQUID, MILD ODOR
Percent Volatiles by Volume:45.55%

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDANTS, ACIDS, BASES.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONOXIDE AND TOXIC VAPORS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSAL OF THIS MATERIAL OR ITS CONTAINERS
REQUIRES COMPLIANCE WITH APPLICABLE LABELING, PACKAGING AND
RECORDKEEPING STANDARDS.

Toxicological Information:NA

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:AVOID DISCHARGE TO NATURAL WATERS.

SARA Title III Information:PURSUANT TO TITTLE THREE OF THE SUPERFUND
AMMENDMENT AND REAUTHORIZATION ACT OF 1986 (SARA) AND 40 CFR PART
372, THIS PRODUCT CONTAINS, OR MAY CONTAIN A TOXIC CHEMICAL IN THE
QUANTITY SUBJECT TO THE R EPORTING REQUIREMENTS UNDER SECTION 313.
Federal Regulatory Information:US POSTAL REGULATIONS: NON-HAZARDOUS,
NON-FLAMMABLE, OKAY TO SHIP BY MAIL.